[1]董良飞,周凯迪.新型厌氧膜生物反应器城市污泥消化研究[J].常州大学学报(自然科学版),2018,30(01):1-8.[doi:10.3969/j.issn.2095-0411.2018.01.001]
　DONG Liangfei,ZHOU Kaidi.Research on Sludge Digestion Using New Anaerobic Membrane Bioreactor[J].Journal of Changzhou University(Natural Science Edition),2018,30(01):1-8.[doi:10.3969/j.issn.2095-0411.2018.01.001]
点击复制

新型厌氧膜生物反应器城市污泥消化研究()
分享到：

常州大学学报(自然科学版)[ISSN:2095-0411/CN:32-1822/N]

卷:
第30卷
期数:
2018年01期
页码:
1-8
栏目:
环境科学与工程
出版日期:
2018-01-28

文章信息/Info

Title:
Research on Sludge Digestion Using New Anaerobic Membrane Bioreactor
作者:
董良飞; 周凯迪
常州大学 环境与安全工程学院,江苏 常州 213164
Author(s):
DONG Liangfei;  ZHOU Kaidi
School of Environmental & Safety Engineering, Changzhou University, Changzhou 213164, China
关键词:
厌氧膜生物反应器;  剩余污泥;  厌氧消化;  转盘膜过滤器;  出水回用
Keywords:
anaerobic membrane bioreactor;  excess sludge;  anaerobic digestion;  rotary membrane filter;  water reuse
分类号:
X 703
DOI:
10.3969/j.issn.2095-0411.2018.01.001
文献标志码:
A
摘要:
基于转盘膜过滤和沼气升流循环搅拌技术构建了新型厌氧膜生物反应器,厌氧消化反应器有效容积为20 L,膜有效面积为0.55 m2。采用该反应器对某城市污水厂的剩余污泥进行厌氧消化处理,考察了膜过滤、厌氧消化过程参数、污泥特性和出水水质等的变化情况。结果表明:当温度为30 ℃、污泥浓度为10.3 g/L时转盘膜组件的临界通量在18～21 L/(m2·h)之间; 运行周期内污泥混合液ρ(MLVSS):ρ(MLSS)由0.61下降到0.42,挥发性固体的累积降解率为58%; 污泥过滤比阻从消化前的2.93×1015 m/kg下降至9.59×1014,有效改善了剩余污泥的过滤性能; 滤液中COD,TN,NH+4-N,TP的平均质量浓度分别为266,514,247,84 mg/L。新型厌氧膜生物反应器对剩余污泥具有良好的消化效果,可以达到较高的有机物降解率并改善污泥的过滤性能,出水经消毒处理后可以应用于园林绿化或农业生产,充分利用其营养物质。
Abstract:
A new type of anaerobic membrane bioreactor was constructed based on rotary membrane filtration and biogas up-flow circulation stirring technology. The effective volume of the reactor is 20L and the effective area of the membrane is 0.55 m2. Anaerobic digestion of excess sludge from a municipal wastewater treatment plant in Changzhou was carried out by using this new anaerobic membrane bioreactor. And the efficiency of anaerobic digestion was investigated from the following aspects: membrane filtration, parameters of anaerobic digestion process, sludge characteristics and the quality of effluent. The results showed that the critical flux of rotary membrane module was between 18 and 21 L/(m2·h)when the temperature was 30 ℃ and the sludge concentration was 10.3 g/L. During the whole operation, the sludge mixture ρ(MLVSS):ρ(MLSS)decreased from 0.61 to 0.42 and the cumulative degradation rate of VS was 58%. The specific resistance to filtration of the sludge decreased from 2.93×1015m/kg to 9.59×1014 m/kg, which effectively improved the filtration performance of the sludge. The average concentration of COD, TN, NH+4-N and TP in the filtrate were 266,514,247,84 mg/L, respectively. On the whole, the new anaerobic membrane bioreactor has good digestion effect on the excess sludge, which can achieve higher organic degradation rate and improve sludge filtration performance. Moreover, the effluent can be applied to landscaping or agricultural production after disinfection and its nutrients can be fully utilized.

参考文献/References:

[1] 袁博, 李靖, 郭强. 厌氧膜生物反应器在废水处理中的研究及发展方向[J]. 工业水处理, 2015, 35(10): 1-6.
[2]纪超. 厌氧和好氧MBR处理生活污水的运行效果及膜污染特性比较研究[D]. 哈尔滨: 哈尔滨工业大学, 2011.
[3]白玲, 蓝伟光, 万金保. 厌氧膜生物反应器在废水处理中的研究进展[J]. 工业水处理, 2007, 27(9): 16-20.
[4]KIM J, KIM K, YE H, et al. Anaerobic fluidized bed membrane bioreactor for wastewater treatment[J]. Environmental Science and Technology, 2011, 45: 576-581.
[5]HU S W, YANG F L, LIU S T, et al. The development of a novel hybrid aerating membrane-anaerobic baffled reactor for the simultaneous nitrogen and organic carbon removal from wastewater[J]. Water Research, 2009, 43(2): 381-388.
[6]余智勇. 厌氧膜生物反应器的污泥消化和膜污染特性[D]. 北京: 清华大学, 2015.
[7]宋永辉. 聚醚砜平板膜生物反应器临界通量的试验研究[D]. 南京: 南京大学, 2011.
[8]XIAO X, HUANG Z, RUAN W, et al. Evaluation and characterization during the anaerobic digestion of high-strength kitchen waste slurry via a pilot-scale anaerobic membrane bioreactor[J]. Bioresour Technol, 2015, 193: 234-242.
[9]DAGNEW M, PARKER W J, SETO P. A pilot study of anaerobic membrane digesters for concurrent thickening and digestion of waste activated sludge(WAS)[J]. Water Science and Technology, 2010, 61(6): 1451-1458.
[10]戴前进, 李艺, 方先金. 城市污水处理厂剩余污泥厌氧消化试验研究[J]. 中国给水排水, 2006, 22(23): 95-98.
[11]李贺. 剩余污泥厌氧消化试验研究[D]. 长春: 吉林建筑工程学院, 2009.
[12]AKIRA H, KAZUHISA M, QING D, et al. Performance of anaerobic membrane bioreactor during digestion and thickening of aerobic membrane bioreactor excess sludge[J]. Bioresource Technology, 2016, 218: 476-479.

相似文献/References:

[1]仲慧赟,葛玉龙,董良飞.中试厌氧膜生物反应器处理养猪废水效能与微生物群落演替[J].常州大学学报(自然科学版),2024,36(04):16.[doi:10.3969/j.issn.2095-0411.2024.04.003]
　ZHONG Huiyun,GE Yulong,DONG Liangfei.Performance of a pilot-scale anaerobic membrane bioreactor treating swine wastewater and the microbial community evolution[J].Journal of Changzhou University(Natural Science Edition),2024,36(01):16.[doi:10.3969/j.issn.2095-0411.2024.04.003]

备注/Memo

备注/Memo:
收稿日期:2017-08-10。
基金项目:江苏省科技成果转化专项资金项目(BA2017006); 常州市国际科技合作计划项目(CZ20150015)。
作者简介:董良飞(1972—),男,江苏沛县人,博士,教授。E-mail: dlf@cczu.edu.cn
更新日期/Last Update: 2018-02-20