[1]李恩田,胡永生,石利新,等.减压膜蒸馏法处理MDEA脱硫液的试验研究[J].常州大学学报(自然科学版),2020,32(02):60-67.[doi:10.3969/j.issn.2095-0411.2020.02.008]
　LI Entian,HU Yongsheng,SHI Lixin,et al.Experimental Study on Treatment of MDEA Desulfurization Solution by Vacuum Membrane Distillation[J].Journal of Changzhou University(Natural Science Edition),2020,32(02):60-67.[doi:10.3969/j.issn.2095-0411.2020.02.008]
点击复制

减压膜蒸馏法处理MDEA脱硫液的试验研究()
分享到：

常州大学学报(自然科学版)[ISSN:2095-0411/CN:32-1822/N]

卷:
第32卷
期数:
2020年02期
页码:
60-67
栏目:
石油与天然气工程
出版日期:
2020-03-28

文章信息/Info

Title:
Experimental Study on Treatment of MDEA Desulfurization Solution by Vacuum Membrane Distillation
文章编号:
2095-0411(2020)02-0060-08
作者:
李恩田; 胡永生; 石利新; 王鲁超; 梁方舟; 朱媛媛
(常州大学 江苏省油气储运技术重点实验室,江苏 常州 213164)
Author(s):
LI Entian;  HU Yongsheng;  SHI Lixin;  WANG Luchao;  LIANG Fangzhou;  ZHU Yuanyuan
(Jiangsu Key Laboratory of Oil & Gas Storage and Transportation Technology, Changzhou University, Changzhou 213164, China)
关键词:
减压膜蒸馏;  再生;  MDEA;  脱硫
Keywords:
vacuum membrane distillation;  regenerate;  MDEA;  desulphurization
分类号:
X 742
DOI:
10.3969/j.issn.2095-0411.2020.02.008
文献标志码:
A
摘要:
选用聚丙烯(PP)中空纤维膜组件为再生器,以吸收了SO2的甲基二乙醇胺(MDEA)富液为研究对象,引用分离因子分析SO2的分离效果,分别考察富液流速、温度、初始SO2浓度及膜两侧真空度对聚丙烯(PP)中空纤维膜分离因子以及脱硫率的影响,并确定最佳工艺参数。实验得出了分离因子随温度、真空度增大而减小,流速以及初始SO2浓度对分离因子影响不大; 减压膜蒸馏再生MDEA脱SO2富液的最佳工艺参数为:温度60 ℃,进料流速250 mL/min,冷侧真空度为60 kPa,初始SO2浓度为0.1 mol/L,在该工艺下脱硫率可达92%以上。实验结束后对减压膜蒸馏实验的膜组件进行清洗,清洗过程完成后,考察膜通量的恢复率,平均膜通量恢复率在75%以上。
Abstract:
Polypropylene(PP)hollow fiber membrane module was used as regenerator, and methyl diethanolamine(MDEA)rich liquid absorbed SO2 was taken as the research object. The separation effect of SO2 was analyzed by using separation factor analysis. The effects of liquid flow rate, temperature, initial SO2 concentration, the vacuum degree on the separation factors of polypropylene(PP)hollow fiber membrane and the effect of desulfurization rate were investigated, and the best process parameters were determined. The experimental results show that the separation factor decreases with the increase of temperature and vacuum, and the flow rate and initial SO2 concentration have little effect on the separation factor. The optimum technological parameters of MDEA desulfurization rich liquor regeneration by vacuum membrane distillation are as follows: temperature 60 ℃, feed flow rate 250mL/min, cold side vacuum 60 kPa, initial SO2 concentration 0.1 mol/L. The sulphur rate can be over 92%. After the experiment, the membrane module of vacuum membrane distillation was cleaned. After the cleaning process was completed, the recovery rate of pure water membrane flux was investigated. The average recovery rate of membrane flux was more than 75%.

参考文献/References:

[1]王寿喜,汤林,JOHN C.酸气回注技术发展现状及其在中国的应用前景[J].天然气工业,2013,33(1):105-111.
[2]ZOU C N, YANG Z, ZHU R K, et al. Progress in China's unconventional oil & gas exploration and development and theoretical technologies[J]. Chemical Engineering Journal, 2015, 89(3): 938-971.
[3]蔡培,王树立,韩永嘉. 膜蒸馏技术回收MDEA的实验研究[J].天然气化工(C1化学与化工),2010,34(1):25-28.
[4]冉旭.基于旋流板塔的有机脱硫剂烟气脱硫性能研究[D].大连:大连理工大学,2012.
[5]裴晓梅,江明,张亚雷. 中国能源的问题与未来[J]. 冶金能源, 2005,24(1):3-5.
[6]AL-RAWAJFEH A E,GLADE H,ULRICH J. CO2 release in multiple-effect distillers controlled by mass transfer with chemical reaction[J].Desalination,2003, 156:109-123.
[7]DERKS P, KLEINGELDA T, VAN AKEN C,et al. Kinetic of absorption of carbon dioxide in aqueous piperazine solutions[J].Chemical Engineering Science, 2006,61(20): 6837-6854.
[8]朱春燕,赵之平,刘殿中,等.膜蒸馏过程传递机理研究进展(Ⅲ)真空膜蒸馏[J].膜科学与技术,2009,29(6):99-104.
[9]符秀兰. 脱硫溶剂MDEA的再生工艺[J]. 硫磷设计与粉体工程, 2007,4:30-33,50.
[10]NAVAZA J M, GÓMEZ-DÍAZD, RUBIA M D L. Removal process of CO2 using MDEA aqueous solutions in a bubble column reactor[J]. Chemical Engineering Journal, 2008, 40(4): 1-5.
[11]EI-BOURAWI M S, DING Z, MA R, et al. A framework for better understanding membrane distillation separation process[J]. Journal of Membrane Science, 2006,285:24-29.
[12]刘捷,武春瑞,吕晓龙.减压膜蒸馏传热传质过程[J].化工学报,2011,62(4):908-914.
[13]SEMA T, NAAMI A, FU K Y, et al. Comprehensive mass transfer and reaction kinetics studies of CO2 absorption into aqueous solutions of blended MDEA/MEA[J]. Chemical Engineering Journal, 2012, 209: 501-512.
[14]徐丽.疏水微孔膜的制备及其在膜蒸馏中的应用[D]. 杭州:浙江大学, 2007.
[15]马琳,秦国彤.膜污染的机理和数学模型研究进展[J].水处理技术,2007,3(6):1-4.
[16]MENGUAL J I, KHAYET M, GODINO M P. Heat and mass transfer in vacuum membrane distillation[J].Int J Heat Mass Transfer,2004,47:865-875.
[17]GRYTA M. Concentration of saline wastewater from the production of heparin[J]. Desalination, 2000,129(1):35-44.

相似文献/References:

[1]徐圃青,谢翠萍.集中污水处理厂尾水再生回用的技术与经济分析[J].常州大学学报(自然科学版),2013,(02):31.[doi:10.3969/j.issn.2095-0411.2013.02.008]
　XU Pu qing,XIE Cui ping.Technical and Economic Analysis of Reclaimed Water Reuse inMunicipal Sewage Plant[J].Journal of Changzhou University(Natural Science Edition),2013,(02):31.[doi:10.3969/j.issn.2095-0411.2013.02.008]
[2]王树立,马 路,江光世,等.膜蒸馏MDEA脱硫剂再生技术实验研究[J].常州大学学报(自然科学版),2012,(01):42.
　WANG Shu-li,MA Lu,JIANG Guang-shi,et al.Study on Regeneration MDEA Solution UsingMembrane Distillation[J].Journal of Changzhou University(Natural Science Edition),2012,(02):42.
[3]李英柳,李爱莲,吴凤丽.Fe3+ 改性TiO2 光催化降解甲醛废水试验研究[J].常州大学学报(自然科学版),2006,(02):19.
　LI Ying- liu,LI Ai- lian,WU Feng- li.Experimental Study of Photocatalytic Oxidation of Formaldehyde over TiO2 modified with Fe3+[J].Journal of Changzhou University(Natural Science Edition),2006,(02):19.

备注/Memo

备注/Memo:
收稿日期:2019-07-31。
基金项目:江苏省研究生科研创新项目资助(KYCX19_1787)。
作者简介:李恩田(1977—),男,湖南南县人,副教授。E-mail:let@cczu.edu.cn
更新日期/Last Update: 2020-04-28